OTISSKY1电梯故障代码大全及主板指示灯及开关说明.docx
- 文档编号:1954317
- 上传时间:2022-10-25
- 格式:DOCX
- 页数:45
- 大小:50.27KB
OTISSKY1电梯故障代码大全及主板指示灯及开关说明.docx
《OTISSKY1电梯故障代码大全及主板指示灯及开关说明.docx》由会员分享,可在线阅读,更多相关《OTISSKY1电梯故障代码大全及主板指示灯及开关说明.docx(45页珍藏版)》请在冰豆网上搜索。
OTISSKY1电梯故障代码大全及主板指示灯及开关说明
OTISSKY电梯故障代码
闪烁的信息
可能的原因
TCI-Lock
轿顶检修开关操作顺序不准确,必须按以下顺序操作
1.打开厅门•2.轿顶检修开关由检修打到正常状况3关闭厅门
如果不按照上面的顺序操作,电梯将不能正常运行,同时LCBII板上的INS指示灯将会闪烁。
LS-Fault
:
a)上强迫减速2LS和下强迫减速1LS信号不正常
startDCS!
a)在没有完成门检查启动(DCS)操作之前正常运行不允许.
b)正常操作时,当电梯停在门区且轿厢门完全打开(DOL有效)时,厅门门全闭信号被触发(DW有效).此时小心检查井道厅门门锁是否被短路•
按M-1-3-5启动DCS!
1LS+2LSon
限位开关1LS和2LS同时动作.
DBP-Fault
电梯运行必须按正确的顺序完成.
当电梯减速停车时门区信号没有被检测,这个原因可能是
LVC继电器故障.
这个错误事件被存储在LCBIIEEPROM上,只能使用检修INS开关来进行电梯操作•
DBSS-Fault
:
变频器没有准备•
Adr.-Check
特殊远程站地址没有对应于标准IO列表
TCI(691)=16-3,1LS(692)=16-1,2LS(693)=16-2,
SE-Fault
电梯因丢失SE信号不能启动(检查SKL,THB,doorbypass,保险丝,)
闪烁的信息英文说明
10.2.2.5BlinkingEventMessages
ThefollowingmessagessreblinkinginejhchstatusdisplayofttieServiceTool:
Blink-
Description
relatedsetup
wrongBoord
ThesoftwarecannoTidentifyttieboard9rsolacettieTCBC.
wroitQE2P
TieEEFROMhasnotthecorrectsize
MHOactive
TheSFBreqiieststoignoreTheinputsatManualF?
escueRun.
LearnRun
a)ThedrivepackageisperfomninqitsLearnRuntoleamIhehoish^aysituation
tDThedrivepackageisadjustingtheencoder
->Aaituntiltheteamrunhjscompleted
DRV^TYF^O
DoorBridge
DWorDFCinputhasnotbeenlav/whileUiedoorwasevened.Reasonis◎bncige-cfQaorloch
->checksafetychain
->Thiseven?
isstprecSintoEEFROMsottiattheONLYytoi^ringTheels1*-atorintooperationag^inisbyusingIlMS.
SwitchHNS
Landingdoorv»'a&operedforlongerthan斗seconcisor:
ltm匚日-dcn:
RimI-■dz:
^d.i^l&ri?
csl-e-_■:
■'.!
:
ice
->ThiseventisstoredintoEEPROMsothattKe
ONLYwa/tobringtheelevatorIntooperationnis
byusingIMS.
TCI-IOCK
TnesequenceTolea^eTci-mcodewasnot匚orrectlyfollowed
i.opondocr
2.switchTCIoff
3.closedooi
TUM"TDM
Oneorthetriqaernx^dulsrupordown)RSLinputsc*9t«ct&€lafailureforr«<1uc9d
->checke-vesntlogi/switchtoEROtoreset(lifterso・”lng)-
l-WY-TYKios1O4T-1051
1IS^-2LSoil
Limitswiftches1LSand2LSar&activeattr*esame:
ime.Cn&ckpower-supplyofth&positionreferencesystem.
TCI-CKfitk
TheROLI/OTCIha^etobe-programmccltoavalidaadressandarenotallowed(oheseitooo-oorui-o.TCIcanbesetto000onlyfortheinstallationphase(tocuninTCIwitKioiitFiS^L>.
->SetI/Oti-QItoavali^laddress
Tai SE-Faull Trit! CrSfcannotSrtartuuetoimssiiigSE-siynal->Cti&cktriedoorbyoass ITM-Fauif TneDBR-contact^ehienisconnectedtntheinput1TH血opcrcd.Thedriveiapowereddov/ntooillowcoding. 2TH-FOult Or'iHofthecxintaccswFiictiiscon*阳匚wkJloIh曰2THisooened. avo ThedrivopackoigQcurrentlyswrlctiedofftosave ■eneirgi产 PDRD startU(LS! ajMomaloperationisnotana-weduntiltneooorcneekSeauencehasteencompletedsuccessfully. t>)TheDCS♦停requiredifoneoftri©p^ram^t&r& TOP*orDOTTOM皿cihan^ed ->EidtfiM-1-3-Slei臥miI(IleDCSI Shutdown ThedrivereoortsmShutdcwrorCAN-Commun(cabonnotv/orking ->SeeeventloggingofMCB. ->jIiujK.CrATs-v/lintj ->checkOAN-LtLiS CmLi(jht CjrLi-ghtR^layontopofeardroppe-d. CLR(1000) USGACSP-2 LginBeamG已怕nasbeenactive. LBG (967.9吁日) SPBrHTS H^illT&miperaturaSensorfromServicePa.nelBoardisaativaterci.C^arinshutdownatne>rtcoimmittableflooranrdtakenljuiLorserviceufiulmetomiptjiaQurtiislowt=! iinam口arame: erSPB-Temp SPB-Temp rr・石孑刖匸 SPB-Comrr, CAN-CQmmuriJcatiQntoSPBisnot/r'onkin^,->checkCAN-^nring->checkCAN-LEDs 10.2.2.6EventLogging TheeventloggingoftheServiceToolcancontainthefollowingmessages: event reason relatedsetup totalruns totalnumborofnunssincelastpoweron - minuteson minutessincelastpoweron - OperatingSystem 0000TaskTiming softwareenteredendessloop 0001WDogRe^et watchdogcircuitonTCBCwastriggered 0002IllegalInt illegalinteruptv.asexecuted 0003CanTxFull CANmessagescannotbesent 0004CanBusOff CANcommunicationhasbeenrestarted 0005WrongE2P AwrongtypeofE2Prom(eg28C64askna'Arfromotherbeards)beendete亡tedonthe board.Thecorrecttypeis28C256.Withthissoftwareversion,nomalfunctionswilloccurwiththewrongE2Prom,butfuturesoftwareversionsmayrequirethecorrectE2Prom. 今InsertthecorrectE2Prom.SeeBRDfororderinqdetails. 0010MCB-Comm. NoCANconnectiontothedrive - 0011SPB-Comm. NoCANconnectiontotheSPB - OperationalControlSubSystem 0100OpModeNAV OCSS>snotavailableduetodri^efault(egdrive-fault(NR).ThismodeisalsoactiveafterINSbeforetheCORstarts 0101EPOshutd- carisnotabletorunduringEPO;thenextcarisallowedtorecover NU(017) NUSD(018} NUSG;019; 0102OpModeDTC doorwasnotabletoclose(mis&ingDCL.DFC
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- OTISSKY1 电梯 故障 代码 大全 主板 指示灯 开关 说明