电池规格书模板文档格式.docx
- 文档编号:18208874
- 上传时间:2022-12-14
- 格式:DOCX
- 页数:21
- 大小:275.54KB
电池规格书模板文档格式.docx
《电池规格书模板文档格式.docx》由会员分享,可在线阅读,更多相关《电池规格书模板文档格式.docx(21页珍藏版)》请在冰豆网上搜索。
~
】
Catalogue目录
。
<
1.Batterytypeandscope电池型号和适用范围
ThisSpecificationApprovalSheetisforrechargeableLi-polymerbatteryprovidedbyShiruiBatteryCo.,LTD.
ThisproductisaccordingwiththenationalstandardofPRC.‘GB/T18287-2000’.‘Generalspecificationoflithium-ionbatteryforcellularphone’.
本《规格书》为时瑞电池有限公司提供的可充电式锂离子电池规格。
此产品符合中华人民共和国国家标准‘GB/T18287-2000’《蜂窝电话用锂离子电池总规范》。
1.:
model产品型号:
2.Basiccharacterandcomposeofbattery电池的基本特性及组成
2.1:
fundamentalperformanceparameterofbattery电池基本性能参数:
S/N
序号
Details
内容
parameters
参数
remarks
备注
.
1
Ratedvoltage
额定电压
2
Ratedcapacity
额定容量
dischargewith0.2CtoafterCompletechargewithin1h,measuringthedischargepower
、
完全充电后1小时内,用0.2C放电至,测量其放电电量。
截止电压
chargevoltage
充电限制电压
4
internalresistance
内阻
≤150mΩ
5
chargemode
充电方式
恒流/恒压方式
)
恒流/恒压
6
Chargetime
充电时间
6H
Standardcharging0.2C280mA
标准充电0.2C(280mA)
}
1C(280mA)
7
MaxChargeCurrent
最大充电电流
1400mA
9
Maxdischargecurrent
最大放电电流
Lasting持续:
Transientpeak瞬间峰值:
2800mA
10
Workingtemperature
工作温度
charging充电时
0~45℃
discharging放电时
-20~60℃
11
Storagetemperature
贮存温度
1Month一个月
Chargeto40%~50%ofcapacitywhenstorage
贮存时应充电至容量的40%~50%
6months六个月
-20~30℃
12
Storagehumidity
贮存湿度
Relativehumidity
65±
20%RH
:
relativehumidity
相对湿度
13
weight
重量
约32g
14
Self-discharging
自放电
Whenthebatterypackiswithoutload,certainoperationalcurrentisconsumedsincethecellprotectsthecircuit,thusleadingtothebringingdownofpackvoltage.Forlongstoringtime,pleasesupplementthechargingandnotethe“seventh.Specialnotice”
Packbeforeshipping
出贷标准
Chargedwithabout25-35%powerandthevoltageisVbeingshipping.
15
Identifyresistance
ID识别电阻
68KΩ
Toground
¥
16
Cyclelife
循环寿命
300times
300循环次
capacity≥60﹪
容量≥60﹪
Ifyouneedthebatteryprotectionparameters,pleaserefertoPAGE11.
如需参考电池保护参数,请参阅第11页。
2.2:
Maincomponentsandparts主要零部件
Materials
材料材料
model
型号规格
quantity
@
数量
relatedtechnicalparameters
相关技术参数
manufacturer
厂商
li-ionbatterycell
锂离子电池芯
484461AR
1PCS
Pleaserefertothebatterycellspecification
请参照电芯规格书
/
protectionboard
保护板
XHY-FHLN-4L
2.3:
Regularperformanceandunfailingperformance产品常规性能和可靠性能
inspectionitem
检验项目
Standard
标准
TestingMethod
测试方法
hightemperatureproperty
高温性能
dischargewith0.5C5Anotlessthan100minsunder55+2℃,theappearancewithoutdistortionandcrack.
电池在55±
2℃,用0.5C5A放电时间不少于102min,电池外观无变形、无爆裂.
setthebattery2hintheenvironmentwith55±
2℃afterCompletecharge,thendischargewith0.5C5A
完全充电后置于55±
2℃,2h用0.5C5A放电
Lowtemperatureproperty
低温性能
dischargewith0.2C5Anotlessthan3hunder-20±
2℃,theappearancewithoutdistortionandcrack.
电池在-20±
2℃,用0.2C5A放电时间不少于3h,电池外观无变形、无爆裂.
setthebattery16-24hintheenvironmentwith-20±
2℃afterCompletecharge,thendischargewith0.5C5A,thensetthebatteryin20±
5℃,2hlaterobservethebatteryappearance
完全充电后置于-20±
2℃,16-24h用放电,结束后将电池置于20±
5℃条件下搁置2h,观察电池外观.
dischargewith0.2C5Anotlessthanunder-10±
2℃,theappearancewithoutdistortionandcrack
在-10±
2℃,用0.2C5A放电时间不少于,电池外观无变形、无爆裂.
setthebattery16-24hintheenvironmentwith-10±
5℃,2hlaterobservethebatteryappearance
完全充电后置于-10±
2℃,16-24h用0.2C5A放电,结束后将电池置于20±
3
Capabilityofkeepingelectricity
荷电保持能力
Dischargenotlessthan
放电时间不少于
Opencircuit28dundertheenvironmentwith20±
5℃aftercompletecharge,thendischargewith0.2C5A
完全充电后,在20±
5℃条件下,将电开路搁置28d,再0.2C5A放电.
Constantdampandhotproperty
恒定湿热性能
Batteryappearanceshouldhavenoobviousdeformation,rust,smokeorexplosion,dischargetimenotlessthan36min
《
电池外观应无明显变形、锈蚀、冒烟或爆炸,放电时间不低于36min.
Aftercompletecharge,shelvethebatteryintheconditionof40±
2℃Relativehumidityis90%-95%withconstanttemperatureandhumidity,48hlater,shelveitin20±
5℃2h,thendischargewith1C5A
完全充电后,在40±
2℃,相对湿度为90%-95%的恒温恒湿条件下搁置48h后,再取出放在20±
5℃条件下搁置2h再以1C5A放电.
shake
振动
Batteryappearanceshouldhavenoobviousdeformation,rust,smokeorexplosion,voltagenotlessthan
电池外观应无明显变形、冒烟或爆炸,电池电压不低于.
Afterfullychargedwith0.38mmamplitude,make10Hz~30Hzresonantfrequency,batteriesinstalledinvibrationbench,setupthreedirectionfromswept-frequencyratefor1oct/min,circularsweepfrequencyvibration30min
\
完全充电后,以0.38mm振幅作谐振10Hz~55Hz的频率,将电池安装在振动台上,设置好三个方向上从扫频速率为1oct/min,循还扫频振动30min
FreeDropTest
自由跌落
Batteryappearanceshouldhavenoleakage,nosmokeorexplosion,butallowedslightdeformation
电池允许轻微变形,但应不漏液,不冒烟,不爆炸。
Aftercrashtest,thesamplebatteriesaredroppedonthe18-20mmhardwoodoftheconcertfloorfrom1000mmheightaccordingtopositiveandnegative6directionofX,Y,Z.Eachdirectionshouldtestonetime.
碰撞试验结束后,将样品电池从1000mm高处自由跌落于水泥地面上的18-20mm厚的硬木板上,从X,Y,Z正负六个方向每个方向1次.
%
Performanceofoverchargeprotection
过充电保护性能
Batteriesshouldbenoexplosion,nofire,nosmokeorleakage
电池应不爆炸,不起火,不冒烟或漏液.
Afterthebatteryisfullycharged,thebatteryshouldbeloaded8hwithconstantcurrentsource.Theconstantcurrentsourcesetsto2timesnominalvoltageandcurrentsets2CA.
$
电池完全充电结束后,用恒流恒压源给电池加载8h,恒流恒源设定为2倍标称电压,电流设定为2C5A
8
Performanceofover-dischargeprotection
过放电保护性能
Batteriesshouldbenoexplosion,nofire,nosmokeorleakage.
Undertheconditionsofanambienttemperature20±
5℃,thebatterydischargeintheconditionsof0.2C5Auntilvoltageistermination.Andthen,batterydischarge24hwithconnectinga30Ωloadresistance.
电池在环境温度20±
5℃的条件下,以0.2C5A放电至终止电压后,外接30Ω负载电阻放电24h.
·
Performanceofshort-circuitprotection
短路保护性能
Batteriesshouldbenoexplosion,nofire,nosmokeorleakage;
batteriesvoltageisnotlessthanN*afterinstantaneouscharge.
电池应不爆炸,不起火,不冒烟或漏液;
瞬时充电后电池电压不低于N*.
Afterbatteryisfullycharge,positiveandnegativeelectrodeshouldbecircuit1hwithΩ.And,batteryshouldbecharged5Sinstantaneouswith1C5Aafterpositiveandnegativeelectrodearecutoff.
电池完全充电后,将正负极用Ω电阻短路1h,将正负极断开后,电池以1C5A电流瞬时充电5S.
Short-circuitTest
短路
Nofire,Noexplosion
Theoutsidetemperatureof
batteryisnothigher150℃.
不起火,不爆炸,电池外部温度不高于150℃.
Keeptheconnectedelectriccouplebatteryinafumehoodandmakepositiveandnegativeshortcircuit(thetotalresistanceshouldbelessthan50mΩ).Testershouldmonitortemperaturechanges.Ifthetemperatureofbatterydropstoabout10℃lowerthanthemaxtemperature,testisfinished.
本项试验将接有电热偶的电池置于通风橱中,短路其正负极(线路总电阻不大于50mΩ),监视温度变化,当电池温度下降到比峰值低约10℃时,试验结束.
Charginglifecycleisover300times
循环寿命不低于300次
容量大于60%.
After300cycle,
Capacity≥60%
Thebatteryusedfortestingofcyclelifeshouldbechargedwithconstantatconstanttemperatureof20℃±
5℃.
Thebatteryischargedwithconstantvoltagetill20mAwhenitischargedtothelimitedvoltage.Thendischargeitwithconstant0.5C5Atilltheendvoltageafterstopchargingfor,repeatthenextcycle.Itmeansthedischargingtimelessthan36minoftwoconsecutivecycleswhilereachingitsendofthelife.
电池循环寿命试验应在20℃±
5℃,以充电,当电池端电压达到充电限制电压时,改为恒压充电,直到充电电流小于或等于20mA,停止充电搁置,然后以0.5C5A电流放电至终止电压,放电结束后,搁置,再进行下一个循环,直至连续两次放电时间小于36min.则认为寿命终止.
Storage
贮存
Fully
charge
the
battery
which
is
new
manufactured
shorter
than
3
months,
with
0.2C,then
discharge
times
less
then
4
hours.
电池贮存3个月,经完全充电后,0.2C5A,放电时间不小于4h.
Thestoragetestofbatteryshouldbeselectedabatterywhichislessthan3monthfromproductiondatetothedateofexperiment.Beforestorage,batterycapacityshouldbefullcharged40%~50%capacity,theambienttemperatureis20℃±
5℃andrelativehumidityis45%-75%.Afterthestorageexpirationofbattery,batteryshouldbechargedanddischargedaccordingtofullychargedanddischarged.
进行贮存试验的电池应选自生产日期到试验日期不足3个月的电池,电池贮存前应按完全充电的40%~50%的容量,在环境温度20℃±
5℃,相对湿度45%-75%的环境中贮存,贮存期满后,电池按完全充放电制进行充放电.
2.4:
ContourDimensionoftheBattery电池外形尺
Label(Nottoscale)标贴
3.SpecificationsofParts零部件规格
3.1:
fenderDW01-P,8205A保护板DW01-P,8205A
3.2:
generalelectricandprotectioncharacters一般电气与保护特征
ModelofProtectionIC:
DW01-P保护IC的型号:
DW01-P
Items
项目
Specification
规格
Remarks
'
Over-chargingProtectionVoltage
过充电保护电压
±
Over-chargingReturnVoltage
过充回复电压
Over-dischargeProtectionVoltage
过放电保护电压
Over-dischargeReturnVoltage
过放回复电压
Over-currentProtection
过电流保护
2-5A
;
DetectionDelayTimeofOver-chargingProtection
过充电保护侦测延时时间
≤200ms
DetectionDelayTimeofOver-dischargingProtection
过放电保护侦测延时时间
≤120mS
DetectionDelayTimeofOver-currentProtection
过电流保护侦测延时时间
≤20mS
DetectionDelayTimeofOutputshort-circuitProtection
输出短路保护侦测延时时间
≤320US(Typical)
InternalResistanceofProperFunctioning
正常工作内阻
≤60mΩ
;
ConsumeCurrent
消耗电流
≤
3.2electricschematicdiagramofbattery电池电路原理图:
PCBlayout电路布局图
TopLayer
Lowerlayer
4.SpecificationsoftheCells电芯规格
NO.
I
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 电池 规格书 模板
![提示](https://static.bdocx.com/images/bang_tan.gif)