风冷冷风型空调机安装使用说明书Word文件下载.docx
- 文档编号:15144030
- 上传时间:2022-10-28
- 格式:DOCX
- 页数:35
- 大小:387.75KB
风冷冷风型空调机安装使用说明书Word文件下载.docx
《风冷冷风型空调机安装使用说明书Word文件下载.docx》由会员分享,可在线阅读,更多相关《风冷冷风型空调机安装使用说明书Word文件下载.docx(35页珍藏版)》请在冰豆网上搜索。
Maintenance
七、运行围………………………………………………………………………….……………...26
Runscope
八、简易故障处理………………………………………………………………………………...27
Troubledisposal
一、机组外观和机组结构 Unitoutlookandstructure
1、机组外观
2、机组结构 Unitstructure
二、系统流程图 systemflowchart
1、风冷冷风型/电加热型空调机工作原理
Workingprincipleoftheair-cooledcoolingorelectricheatingairconditioner
2、热泵型空调机工作原理
Workingprincipleoftheheat-pumpairconditioner
三、机组安装
1.安装空间:
Installationspace
确保机组安装位置周围有足够的空间以备操作、维修之用,同时也要保证气流循环畅通,不受阻碍并且没有短路。
安装空间尺寸参见下图。
Inordertoensureoperationandmaintenanceconvenient,enoughspacearoundtheunitsmustbeensuredwhileinstalling.Airmustflowfreelywithoutresistanceandshortcircuit.Installationspacesizecanbeconsultedasfollows.
型号model
A
B
C
3HP、5HP、8HP、10HP
500
12.5HP、15HP
800
20HP、24HP
1000
25HP、30HP、40HP、50HP
60HP、70HP、80HP、100HP、110HP
1500
注:
假设A为无连接管侧,B为连接管侧。
Note:
assumeAnottobesideofconnectingpipe,
Btobesideofconnectingpipe.
2.安装定位Installinglocation
应考虑电气接线、室外机连接、排水管布置以及风管连接的方便。
确保地面平整、水平,机组安装后倾斜度不应超过下图要求。
Mustcountfortheconvenienceofelectricwiring,connectionofindoorandoutdoorunit,arrangementofdrainpipeandairductconnectionwhileinstallation.Ensuregroundtobeflatandlevel,afterinstalling,unitgradientcannotexceedthelimitshowedinfollowingchart.
地基应有足够的强度。
机组重量和地脚螺钉固定位置参见以下各图。
Foundationshouldbeintendedenough.Unitweightandthefootscrewfixedpositionisshowedasfollowingcharts.
其它注意事项:
Otherattentions
(1)室外机组安装位置要选择适当,必须安装在无日光照射、远离热源的地方。
Indoorandoutdoorunitmustbeinstalledintheplacewhichhasnosunlightilluminatedandfarfromheatresource.
(2)室外机组安装应考虑对建筑物外观的影响。
Theinfluenceonthebuildingappearancemustbeconsideredwheninstalltheoutdoorunit.
(3)安装安置应尽量选在管路短、弯曲少、高差小的地方。
Installationshouldbesituatedinplaceswherethepipeisshort,bendsarefewandtheheightdifferenceislittle.
(4)室外机组的位置不在地面或楼顶平面而需悬挂在墙壁上时,应制作牢固可靠的支架。
Whileoutsideunitisnotinstalledonthegroundorthetopplane,buthungonthewall,itmustusethefirmsupport.
(5)室外机组出风口不应对准强风吹的方向,上面不应有障碍物。
若顶部空间不够时,需安装弯曲型导风管将风导向远处,以避免气流短路而影响机组性能。
Theoutsideunit’sairoutletcouldn’tbeinthedirectionofstrongbreeze,andtherewon’tbeobstaclesaboveit.Iftheabovespaceisnotenough,pleaseinstallbendingtypewindducttoguidethewindtodistance,avoidingthatunitperformancewillbeinfluencedbyairflowshort.
(6)侧出风型室机安装在空调房时,除考虑安装方便外,还要保证气流合理,送风均匀。
Whilesideairoutletmodelindoorunit’sinstallationintheairconditionerroom,exceptconsideringconvenientinstallation,itshouldensureairflowreasonablyandairsupplyequably.
(7)任何情况下,室机组都不能安装在室外。
Inanycase,theinsideunitshouldnotbeinstalledoutside.
3.安装Installation
示例图demonstration
a.搬运、吊装Handling,hoisting
机组可用铲车或吊车运输,吊装时应如下图进行操作。
Unitcanbetransportedbyforkliftorhoist,pleaseoperateasthefollowingchartwhilehoist.
注意事项Attentions
(1)吊装前应检查机体吊环是否旋紧,缆绳是否安装牢固。
Beforehoisting,shouldensuretheorganismringstightened,thehawsersfastened.
(2)搬运或吊装过程中,应保持机体平衡,切勿突然升高、降低或剧烈晃动。
Duringhandlingorhoisting,keeporganismbalance,don’trise,dropsuddenlyorswayviolently.
b.管路布置Pipesarrangement
连接管路的布置须根据现场情况参照以下原则进行:
Connectionpipearrangementmustaccordingtothesite’sconditionandrefertothefollowingprinciples:
(1)尽可能缩短连接管长度,最好在5m以
Trytoshortenthelengthofconnectionpipe,bestwithin5m.
(2)尽可能减小室外机高度差。
Trytoshortenthealtitudedifferencebetweenindoorandoutdoorunits.
(3)尽可能减少连接管路的弯头数。
Trytoreducethejoint’samountusedforconnectionifpossible.
(4)连接管长超过20米时,需检查系统的润滑油是否足够,必要时,需适当增加。
Whenpipelongerthan20m,inspectlubewhetheritisenough,additwhennecessary.
当室外机高度不同时,参照下图进行管路布置。
Ifindoorandoutdoorunit’saltitudesaredifference,arrangethepipelineaccordingtofollowinggraph.
液管(即细管) liquidpipe(thinnerpipe)
------气管(即粗管) gaspipe(thickerpipe)
室外机连接管的高差、管长及弯头数按下表限制:
室外机型号
Outdoorunitmodel
SW-3N
SW-(4X2)N
SW-3RN
SW-5N
SW-(5X2)N
SW-5RN
SW-8N
SW-(6X2)NSW-8RN
SW-10N
SW-10RN
SW-13N
SW-13RN
SW-15N
SW-15RN
SW-20N
SW-20RN
SW-25N
SW-25RN
SW-30N
SW-30RN
SW-60NSW-70NSW-80N
最大管长
Max.pipelength
20
30
40
50
最大高度差
Max.Altitudedoffs.
10
15
25
最多弯头数(90℃)
Max.elbow.meter
6
8
12
Altitu
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- 风冷 冷风 空调机 安装 使用 说明书
![提示](https://static.bdocx.com/images/bang_tan.gif)