Ch 06 教案.docx
- 文档编号:12336533
- 上传时间:2023-04-18
- 格式:DOCX
- 页数:39
- 大小:46.39KB
Ch 06 教案.docx
《Ch 06 教案.docx》由会员分享,可在线阅读,更多相关《Ch 06 教案.docx(39页珍藏版)》请在冰豆网上搜索。
Ch06教案
专业英语第六章教案
单词和词组
Abinitio从头开始
Insequence顺序
Abnormal异常的
Limestone石灰
Admissionvalve进气阀
Localizedcorrosion局部腐蚀
Auxiliary辅助的
Log运行日记
Amyriadof大量的
Lubeoilsystem润滑油系统
Assess评估
Monitor监控
Bevitalof为…不可缺的
Millscale氧化皮
Carryover携带
Mill磨煤机
Category种类
Moisture水分
Controlpanel控制盘
Mandatory强制的
Categorisevt.分类
Megawatt兆瓦
Coldstart冷态启动
Overlaid覆盖
Controllability控制性能
Parameter参数
Commissioning试运行
Parallelin并网
Conservative保守的
Passivation钝化
Console仪表板,控制台
Partandparcelof…的重要部分
Contamination污物
Personnel人员
Condensatestoragetank凝结水箱
Pertinent有关的,相关的
Condensatehotwell凝汽器热井
Procedure规程
Debris碎屑
Preempt先占,抢先
Deposits沉积物
Portion部分
De-aeratorstoragetank除氧器水箱
Plug堵塞
Drainpipe排水管
Pneumatictest气密性试验
di-sodiumphosphate磷酸二钠
Pulverizer磨煤机
Duplicated重置的
Reveal展现
Energize通电,供电
Residue残渣
Electricaldistributionsystem
配电系统
Scrub净化
Erection安装
Seal堵头
Excitation励磁
Silo仓
Feasibility可行性
Silica二氧化硅
Flange法兰
Standstill停机
Finnedsurface扩展受热面
Solubility可溶性
Flush冲洗
Sophisticated完善的
Forceddraftfan送风机
Synchronize同步
Harp竖管排
tri-sodiumphosphate磷酸三钠
Header联箱
Trip事故停机,跳闸
Hose软管
Turninggear盘车
Hotstart热态启动
Utilize使用
Hydrostatictest水压试验
Valveseal阀门密封
Ignition点火
Velocity速度
Induceddraftfan引风机
Vessel容器,管道
Intermittent间歇的
Vendor厂家
Inthevicinityof在附近
Vent排气口
Inorganic无机物的
Void空隙
Initial初始的
Warmstart温态启动
Inparallel并行的
Welding焊接
简写
EPC欧洲专利公约
OEM设备制造厂家
EPO欧洲专利局
PCT专利合作条约
FAQ常见问题解答
RSP再热蒸汽压力
HRSG余热锅炉
RST再热蒸汽温度
MST主蒸汽温度
USC超超临界
MSP主蒸汽压力
VWO阀全开
Chapter6UnitSystemOperation
第六章单元机组运行
6.1Introduction
6.1前言
6.1Intrudction
Forthepowerplanttorunandproduceelectricity,variouscategoriesofmechanical,electrical,andchemicalequipmentineachcategorymustbeplacedintooperationtoperformitsintendedfunction.发电厂运行发电,需要运行大量不同种类的机械、电气和化学设备,
Theoperationoftheequipmentmustbecoordinatedtomeetthedemandoftheelectricityproductionprocess,andtheproductionprocessmustberegulatedsothatthecycleandtheequipmentareoperatedwithindesignconditions.设备运行必须按照电力生产过程的要求进行,生产过程应按设计工况调节工质循环与设备运行
Theplantcontrolsystemprovidesthenecessarytoolstoenabletheoperatorstoorchestrateplantoperationforthereliableandefficientproductionofelectricity.机组控制系统能够使运行人员可靠而高效地组织电厂生产运行
Thischapterprovidesanoverviewoftheplantcontrolsystem,itsfunctions,operationandthetypeofcontrolequipmentusedinamodernpulverizedcoal-firedpowerplant.
本章介绍现代燃煤电厂的控制系统概况、功能、运行和典型设备操作。
6.2BasicControlFunctions
6.2基本控制功能
Inamodernpowerplant,themajorityofthecontrolactionsrequiredtooperatetheprocessesisautomated.在现代的发电厂,大多数运行控制与操作是自动的。
Therearenumerousreasonsforplantautomation.电厂之所以采用自动运行有以下理由:
Firstly,automationreduceshumanerrorinplantoperationandthusprovidesgreatersafetyforplantpersonnel.第一,自动化可以减少人员在运行中误操作,对电厂人员安全提供更大的保障;
Secondly,automationreducesthenumberofoperatorsrequiredtoruntheplant,whichreduceslaborcosts.第二,自动化减少了运行人员的数量,降低了人工费用;
Thirdly,anautomatedprocessismoreefficientthanamanualprocessbecauseautomaticcontrollersarecapableofrespondingtochangesinoperatingconditionsfasterandmoreaccuratelythanhumanoperators.第三,自动化生产过程比人工操作效率高,自动控制系统能够比人更快更准确地应对运行中各种情况变化
Theresultistightercontrolofplantoperatingparameterswhichkeepstheprocessrunningwithindesignconditions.自动运行使电厂运行参数更加接近于设计工况。
Thecontrolfunctionsusedinoperatingapowerplantcanbeclassifiedinmanyways.电厂运行的控制有许多分类方法,
Forthepurposeofthisdiscussion,thefunctionsoftheplantcontrolsystemareclassifiedbytypeofcontrolactionused.为便于讨论,控制系统的功能可按控制功能分类
Inthisrespect,controlfunctionscanbecategorizedintotwodistinctivelydifferentcategories:
on-offcontrolandmodulatingcontrol.这样,控制功能可分为两种截然不同的类型:
启停控制和调节控制,
Bothtypesofcontrolfunctionscanbefoundinapowerplant.这两种控制在电厂都有。
Theon-offcontrolisalsoknownasdigitalcontrol,binarycontrol,discrete[离散]control,sequentialcontrolormotorinterlocks.启停控制又称数字控制、二进制控制、离散控制、顺序控制及电机连锁。
Modulatingcontrolissometimescalledanalogcontrol,continuouscontrol,orclosedloopcontrol.调节控制有时被称为模拟控制、连续控制、闭环控制。
Nostandardindustry-wideterminologyexistsforthesetwotypesofcontrolfunctions.这两种控制在各行各业没有统一的定义。
On-offcontrolproducesacontrolactionthatvariesindiscretestates.启停控制发出一个控制动作指令,
Anexampleofthistypeofcontrolisstartingandstoppingmotor.这类控制的一个例子是开启、停止一台电机。
Thecontrolsystemproduceseitherastartcommandorastopcommand,andthecontrolledequipmentreactstothecommandwithtwodistinctoutcomes:
motorrunningormotorstopped.控制系统发出启动或停机命令,受控设备按命令来进行不同的动作:
电机启动或电机停机。
Nointermediatestateexistsbetweenthe“running”andthe“stopped”state.在启、停状态之间没有中间状态。
教材115页
Modulatingcontrolproducesacontroloutputsignalwithamagnitudethatvariessmoothlyfromonevaluetoanother.调节控制发出一个控制输出信号,该信号值从一个值连续变化到另一个值。
Anexampleofthistypeofcontrolisregulatingwaterflowtoatankbyadjustingthepositionofwatersupplyvalve.该类控制的例子是通过调整给水阀的开度调节到水箱的流量
Thecontrolactioniscontinuouslyadjustingthevalvepositiontomaintainthewaterlevelinthetankatadesiredpoint.控制动作连续调节阀门使水箱水位保持在要求位置。
Thestateofthevalveiscontinuousinthatthepositionofthevalvecanbeanywherebetweenthefullyclosedandthefullyopenposition.
阀门状态是连续的,可以从全关到全开任一位置。
Usingon-offandmodulatingcontroltooperateapowerplantmaybecomparedtoapersondrivinganautomobile.采用启停和调节控制来运行电厂与开汽车类似,
Tostartthecar,thedriverturnsontheignitionkeyandtheenginestarts.Thisison-offcontrol.开车时,司机启动点火钥匙,发动机发动,
Oncetheengineisstartedandthecarisrunning,thedrivercontrolsthespeedofthecarbycontinuouslyadjustingtheacceleratorpositionwheneverthecar’sspeeddeviatesfromthedesiredspeed.Thisismodulatingcontrol.这就是启停控制。
当发动机发动后,汽车开动,只要车速与要求值有偏差,司机会连续调整油门使汽车速度连续变化,这就是调节控制。
Apoweroperatorgoesthroughsimilarstepsinoperatingthepowerplant.电厂运行人员在电厂运行时也进行类似步骤,
Theoperatorstartsapumpmotor,afanmotor,orsomesuchequipment.启动给水泵、风机及其他设备
Typically,theoperatorwaitsuntilapumpisstartedandthenincreasesordecreasestheopeningofavalveatthepumpdischargetoregulatethewaterflowthroughthepump.典型的步骤是:
运行人员在给水泵启动后,按泵的出水流量增减阀门开度来调节泵。
Onsomeoccasions,bothactionscanbeappliedtothesamepieceofequipment.在某些情况下,同一设备可接受全部指令
Acaseinpointisapumpdrivebyavariable-speedmotor.比如当泵由一台变速电机带动时
Theon-offactionisusedtogetthemotorstarted,andthemodulatingactionisappliedtoregulatethepumpingratebyadjustingthemotorspeed.启停控制用来启动电机,调节控制通过调整电机速度来调节泵流量
Theon-offandthemodulatingcontrolactioncomplementeachother.启停、调节控制互相补充
Inthecaseofanemergencyoradesiredshutdown,theon-offcontrolcanshutdownequipmentandputtheprocessinasafeconditionreadyforarestart.在紧急停机或正常停机时,启停控制能使设备停机,并使其保持安全状态以备下一次启动
6.3PlantOperationfromtheControlRoom
6.3电厂主控室运行
Operatorinterfacedevicesarethetoolsthatacontrolroomoperatorusedtomonitorandcontrolplantoperation.主控室操作台是运行人员用来监视与控制电厂运行的工具
Thissectionprovidesabriefrundownoftheactivitiesrelatedtoplantoperationfromcoldstarttofullloadthatrequiretheoperator’sattentionandinteractionwiththeplantequipmentandsystems.本节给出电厂运行的简要说明,包括从冷启动到满负荷运行时的注意事项与电厂设备和系统的相互影响。
Fromthestandpointofoperatorinthecentralcontrolroom,theequipmentandsystemsfallintotwocategories:
从主控室运行人员的观点看,设备和系统分为两类:
thosecontrolledbyalocaloperator,andthosecontrolledbythecontrolroomoperatorsituatedremotefromtheequipment.就地操作和主控室远程操作。
Theformeraremostlytheplantsystemsthatservemorethanoneorallunitsintheplant,andtheiroperationiseitherintermittentortheoutputsdonotvarydirectlywiththemegawattoutputoftheplant.前者大部分是厂内系统,服务1个或几个单元,它们的运行是间断的且与电厂的负荷没有直接关系。
Thoseinthelattercategoryaretheunit-orientedequipmentthatmustbeplacedintoservicewhentheunitisrunningandtheiroperationmustberegulatedastheunitloadchanges.后者是机组运行的主要设备,它们的运行随着电厂负荷变化而变。
6.3.1Commonsystemoperation
6.3.1公共系统运行
Afteraplantisbuilt,itisrarethataunithastobestartedfromavery“cold”conditionwitheverypieceofequipmentatstandstillandeverytankorvesselempty.电厂建成后,很少出现机组从所有设备停机、空水箱的极“冷”态启动。
However,ifthisistheplantconditionatthetimeofaunitstart,theoperatingpersonnelwillhavetoget
教材116页
thesesystemsintooperationbeforedoinganythingelse.Thefollowingstepsshouldbetaken:
如果启动时电厂机组处于这样的冷态,运行人员在其他操作之前必须运行一些系统,应采取以下步骤:
(1)Energizetheplantauxiliaryelectricaldistributionsystembybringinpowerfromanoutsidesourceandpoweringupthecontrolsystems.
(1)首先从电网向厂用电和控制系统供电。
(2)Startthecompressedairsystems(boththestationserviceandthecontrolairsystem)
(2)启动压缩空气系统(包括检修用气和控制用气)。
(3)Makewater(plantservicewaterandcyclemakeupwater)byfirststartingtheplantrawwatersystem(orwellwatersystem,asthecasemaybe)withitsassociatedwatertreatmentsystem.(3)启动电厂生水系统(如井水系统)及水处理系统制水。
(4)Preparecoalhandlingandothermaterial(suchaslimestone)handlingsystemforservice.(4)准备制粉系统及其他材料系统(如石灰)。
(5)Preparetheignitionfuelsystem,andifapplicable,theauxiliaryboilerfuelsystemforservice.(5)准备点火燃油系统和辅助锅炉燃油系统。
(6)Produceauxiliarysteambystartingtheauxiliaryboilerwhentherequiredfuel,water,andcompressedairareready,orbytakingsteamfromothersourcesifavailableintheplant.
(6)当所需煤粉、软化水和压缩空气制备好后,启动辅助锅炉生产辅助蒸汽,也可从电厂其它蒸汽源获得。
Typically,plantcommonsystemsareinstalledwithacontrolcabinetoralocalcontrolpanellocatedinthevicinityofthes
- 配套讲稿:
如PPT文件的首页显示word图标,表示该PPT已包含配套word讲稿。双击word图标可打开word文档。
- 特殊限制:
部分文档作品中含有的国旗、国徽等图片,仅作为作品整体效果示例展示,禁止商用。设计者仅对作品中独创性部分享有著作权。
- 关 键 词:
- Ch 06 教案